自動變速箱作為汽車核心部件之一，其精密結構與復雜工況對駕駛習慣有著極高要求。許多看似平常的操作，實則暗藏?fù)p害變速箱的風險。了解并規避這些行為，是延長變速箱壽命、保障行車安全的關鍵。

　　As one of the core components of automobiles, automatic transmissions have extremely high requirements for driving habits due to their precise structure and complex working conditions. Many seemingly ordinary operations actually carry the risk of damaging the gearbox. Understanding and avoiding these behaviors is the key to extending the lifespan of the gearbox and ensuring driving safety.

　　長時間停車時掛D擋踩剎車是典型的隱性傷害行為。當車輛處于D擋靜止?fàn)顟B(tài)，變速箱油泵因發動機低轉速導致供油壓力不足，液力變矩器持續半聯動狀態會產生大量熱量。某維修機構數據顯示，此類操作持續超過5分鐘，變速箱油溫可能升高15-20℃，加速密封件老化與油液劣化。正確做法應是切換至N擋并拉緊手剎，既減輕變速箱負荷，又避免剎車系統過熱。

　　Stepping on the brake while in D gear during prolonged parking is a typical implicit injury behavior. When the vehicle is in a stationary state in D gear, the transmission oil pump may experience insufficient fuel supply pressure due to low engine speed, and the hydraulic torque converter may generate a large amount of heat if it continues to operate in a semi linked state. According to data from a certain maintenance organization, if such operations continue for more than 5 minutes, the transmission oil temperature may rise by 15-20 ℃, accelerating the aging of seals and oil degradation. The correct approach should be to shift to N gear and tighten the handbrake, which not only reduces the load on the gearbox but also avoids overheating of the braking system.

　　空擋滑行對自動變速箱的損害具有雙重性。傳統認知中空擋滑行可省油，但現代電噴發動機在帶擋滑行時已實現斷油控制，空擋滑行反而使發動機進入怠速噴油狀態，油耗不降反升。更關鍵的是，空擋狀態下變速箱油泵轉速下降70%以上，導致潤滑與冷卻效能急劇降低。某測試顯示，連續5公里空擋滑行后，變速箱油溫可能突破120℃安全閾值，引發離合器片燒蝕風險。

　　The damage caused by coasting in neutral to automatic transmissions has a dual nature. In traditional perception, coasting in neutral can save fuel, but modern electronic fuel injection engines have implemented fuel cut-off control during coasting in neutral. Instead, coasting in neutral causes the engine to enter an idle fuel injection state, resulting in an increase in fuel consumption instead of a decrease. More importantly, when in neutral, the speed of the transmission oil pump drops by more than 70%, resulting in a sharp decrease in lubrication and cooling efficiency. A certain test shows that after 5 consecutive kilometers of coasting in neutral, the transmission oil temperature may exceed the safe threshold of 120 ℃, causing the risk of clutch plate erosion.

　　陡坡停車時先掛P擋再拉手剎的操作順序，是變速箱齒輪的“隱形殺手”。P擋鎖止機構設計用于靜態駐車，若在斜坡未拉手剎時直接掛入P擋，車輛重力將全部作用于駐車棘爪與齒輪。某品牌變速箱工程師指出，這種操作會使棘爪承受超過設計值3倍的應力，長期如此會導致齒輪變形或棘爪斷裂。正確流程應為：腳剎停車→拉緊手剎→掛入P擋→熄火。

　　The sequence of shifting to P gear and then pulling the handbrake when parking on steep slopes is the "invisible killer" of the gearbox gears. The P-gear locking mechanism is designed for static parking. If the handbrake is not applied on a slope and the P-gear is directly engaged, the vehicle's gravity will be fully applied to the parking pawl and gear. A gearbox engineer from a certain brand pointed out that this operation will cause the pawl to bear stress that exceeds the design value by three times, which can lead to gear deformation or pawl fracture in the long run. The correct process should be: parking with foot brake → tightening the handbrake → shifting into P gear → turning off the engine.

　　冷車狀態下急加速是變速箱的“酷刑”。低溫環境下變速箱油粘度劇增，流動性下降50%以上，此時猛踩油門會使離合器片在半聯動狀態產生劇烈摩擦。某實驗室模擬實驗表明，零下10℃環境中冷車急加速，變速箱溫度上升速率是正常工況的2.3倍，10分鐘內即可觸發過熱保護。建議冬季啟動后保持低轉速行駛3-5分鐘，待水溫表指針開始上升后再正常駕駛。

　　Sudden acceleration in a cold state is a torture for the gearbox. In low-temperature environments, the viscosity of transmission oil increases dramatically, and the fluidity decreases by more than 50%. At this time, stepping on the accelerator suddenly will cause severe friction between the clutch plates in a semi linked state. A laboratory simulation experiment showed that in an environment of minus 10 ℃, when a cold car accelerates rapidly, the temperature rise rate of the gearbox is 2.3 times that of normal operating conditions, and overheating protection can be triggered within 10 minutes. It is recommended to drive at low speed for 3-5 minutes after starting in winter, and wait for the water temperature gauge pointer to start rising before driving normally.

　　涉水行駛后不檢查變速箱的疏忽行為可能釀成大禍。自動變速箱通氣孔通常位于上半部，水位超過輪轂中心即有進水風險。某保險公司理賠數據顯示，暴雨后變速箱維修案例中，68%存在進水痕跡。水進入變速箱會與油液混合形成乳化物，導致離合器片打滑、閥體卡滯等故障。涉水后應立即檢查油液狀態，若發現乳白色泡沫需立即更換變速箱油及濾芯。

　　Negligent behavior of not checking the gearbox after driving through water may lead to major accidents. The automatic transmission vent is usually located in the upper half, and there is a risk of water ingress if the water level exceeds the center of the wheel hub. According to the claim data of an insurance company, 68% of the gearbox maintenance cases after rainstorm had traces of water ingress. Water entering the gearbox will mix with the oil to form an emulsion, causing faults such as clutch plate slippage and valve body sticking. Check the oil status immediately after wading. If milky white foam is found, replace the transmission oil and filter element immediately.

　　忽視變速箱油液更換周期是慢性損害的根源。多數車主知曉機油更換周期，卻對變速箱油關注不足。某4S店維修記錄顯示，行駛超10萬公里未換油的車輛中，83%出現變速箱頓挫、異響等問題。自動變速箱油不僅承擔潤滑，還兼具冷卻、液壓傳動功能，長期使用后添加劑失效、金屬碎屑沉積會嚴重降低性能。建議嚴格遵循保養手冊，通常每4-6萬公里或2-3年更換一次。

　　Neglecting the transmission fluid replacement cycle is the root cause of chronic damage. Most car owners are aware of the oil change cycle, but pay insufficient attention to the transmission oil. According to maintenance records from a certain 4S dealership, 83% of vehicles that have driven over 100000 kilometers without changing the oil have experienced issues such as transmission jerking and abnormal noise. Automatic transmission oil not only provides lubrication, but also has cooling and hydraulic transmission functions. After long-term use, additive failure and metal debris deposition will seriously reduce performance. It is recommended to strictly follow the maintenance manual and usually replace it every 40000 to 60000 kilometers or 2-3 years.

　　駕駛習慣對自動變速箱的影響具有累積效應，單次不當操作未必立即顯現故障，但長期積累終將引發質變。培養良好的操作意識：平順起步、避免粗暴駕駛、規范停車流程、定期保養維護，這些細節既是保護變速箱的良方，更是安全行車的基石。記住，變速箱的壽命，就藏在你的每一次操作選擇中。

　　The influence of driving habits on automatic transmissions has a cumulative effect. A single improper operation may not immediately manifest a malfunction, but long-term accumulation will eventually lead to a qualitative change. Developing good operational awareness: smooth starting, avoiding rough driving, standardizing parking procedures, and regular maintenance are not only effective ways to protect the gearbox, but also the cornerstone of safe driving. Remember, the lifespan of the gearbox is hidden in every operational choice you make.

　　本文由濟南自動變速箱維修友情奉獻.更多有關的知識請點擊:http://www.mmolords.cn真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from Jinan Automatic Transmission Maintenance For more information, please click: http://www.mmolords.cn Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.